HEATERS: Flue Pipe with Fins

Culture Orchid Doctor

by Robert M. [Bert] Hamilton (Compiler)

Originally published in The Orchid Doctor in 1980 and 1988

Posted by Sys Admin almost 8 years ago.

Article Blog   Article Index
Make your own: on a roll of lightweight lawn edging aluminum four inches high use shears to cut slits 5/8 in. apart from the lower edge inward for 3in. along a length necessary to wind it up spirally over the flue stack to its top and then secure it with wire, rivets or metal screws; it recovers about 50% of otherwise wasted stack heat. A83-153
Share on Social Media:  
Log in to Add a Comment

More The Orchid Doctor Articles under the Heading Heating

Heating Comments
HEATERS: Back-up for Main Unit If it is ever used in emergency there should be a guarantee obtained from the dealer that it will not produce ethylene when it is used; get a written guarantee. A80-1140 0
HEATERS: Catalytic Type Such as made by Coleman; it is not proven but presumably they should not generate ethylene. A77-922; they are approved for emergency heating, although the amount of heat produced is low. A75-35; A78-1124 0
HEATERS: Emergency Electric heater causes parching of plants; deflect the hot air stream away from plants, increase the humidity; or, try a polyethylene tube prepunched with holes. A77-619Manually operated propane burner would be satisfactory; be sure to provide enough oxygen. A71-439; A71-917; A72-55One or two propane heaters without controls will be satisfactory; natural gas is even preferred. A78-226 0
HEATERS: Emergency, for Greenhouses Aladdin series of kerosene heaters are recommended; should burn properly adjusted. A72-631 0
HEATERS: Emergency System If the emergency heater fails to operate the last hope is to use water as a continual spray over the plants to avoid freezing and to achieve at least survival of the plants; use a follow-up of fungicide on the plants to avoid mass black rot. A83-1183Space heaters capable of running 20 hours at full fire run on gas or propane in which the pilot light activates its own thermostat; details in Ca85(1)-9 0
HEATERS: For Emergency in Case Power Fails Hy-Lo Salamander burns either kerosene or range-oil; it is an ethylene risk; use kerosene; arrange a temporary vent to the outside; burn as bright a flame as possible. A74-114 0
HEATERS: Gas or Propane A gas heater if exclusively methane can be used without venting; propane has up to 0.6% ethylene and needs proper venting A81-1093 0
HEATERS: Gas Space Units A small unit providing 22-to-50,000 BTU in which the pilot light activates a small electrical pile which in turn activates a thermostat called Self Generating, or Capillary Tube, is described, to take either natural gas (must be vented) or propane (which, if unvented, provides 40% more heat with more carbon dioxide and water); refer to Ca85(l)-9 0
HEATERS: Infra-red New Types They are efficient systems that use either natural gas or propane/butane mix to fire burners and a special pipe emits infrared waves which heat the plant benches, the floor, etc,x and not the air; for advt. refer to A84-1337 0
HEATERS: Kerosene New Types A 9000-BTU-per-hour heater can produce sulfur dioxide levels during overnight use, a principal air pollutant which is "controlled" by the U.S. Environment Protection Agency to prevent injury; ventilation of one air eschange per hour is necessary; outside air can take a lot of heating; K-l kerosene can be below standard frequently; sensitive plants are Ludisia discolor, Vanilla planifolia, Dendrobium pierardii, D. primulinum. A82-878Caused sepal wilt and deformation because ethylene gas was emitted; but the Kero-Sun Heater apparently is not supposed to emit ethylene. A81-810Experience indicates problems in greenhouses such as bud-blasting and plant damage caused by sulfur dioxide; carbon dioxide and monoxide are not harmful to plants in lower concentrations. A83-266Modern space heaters in greenhouses should be vented in and out, like a furnace; they consume oxygen and produce noxious fumes. A82-37; -1061; A86-1141Sepal wilt, leaf yellowing both followed an installation; air must be s... 0
HEATERS: Quartz Electric Type It is satisfactory for greenhouse use but perhaps is not adequate because it affects plants only in its pathway and costs more. A81-1093 0
HEATERS: Unvented A heater using natural gas, no shortage of air and a clean burner is satisfactory. A81-266The flame consumes the oxygen in a tight greenhouse and the flame then does not burn properly and fumes begin to build up; so once again, use a vent. A87-290 0
HEATERS: Wood-burning Furnaces In Maine with a possible wind-chill factor of minus 80 dF, a furnace of 125,000 BTU, with hot air, taking a 30inch stick of wood, vented to the outside is described; specifications, names of suppliers, etc. given; you may have to sleep beside it on the worst winter nights. A82-1025 0
HEATERS: Wood-burning Stove It is apt to emit too much ethylene if it is not properly vented; burning wood is one of the worst sources of ethylene; it is now a crime to burn wood for heating purposes in London. A81-1436 0
HEATERS: Wood-burning Stoves They are not recommended because they ruin most orchids unless the draft is fully open at all times to discharge fumes into the neighbour's back yard. A81-526 0
HEATING CABLES: Use for Try growing mature Doritaenopsis and Phalaenopsis in the greenhouse on one for better performance; it should be linked to a thermostat control. OIE85Jy-15; RMH 0
HEATING: Costs and How to Reduce Them Adopt partial underground construction of greenhouses, lots of insulation, a southern exposure, double glazing with plastic film, airtightness, the installation of passive heat storers (steel drums filled with water). A80-100 0
HEATING: Emergency Water will flow till it freezes and as it freezes it releases heat, so saturate the greenhouse with water when the emergency heater conks out on the coldest night; keep it going until heating is resumed. A83-1183 0
HEATING: Emergency Systems An alarm system described, as well as three types of emergency heating apparatus; refer to A64-121+ 0
HEATING: Greenhouses The Kentucky Agricultural Experiment Station's system of heating is fully described and illustrated; refer to A64-547 0
HEATING: Infrared This type heats plants directly instead of the surrounding air; growth doubled and root vigor increased dramatically in one installation; gas consumption is one-tenth of what was used in summer (California); Wll-164; 50% more fuel efficient. Wll-212 0
HEATING: Infra-red Heat In greenhouses it promotes vigor in leaves and roots and flowers at an economical cost; the units use propane/butane, or natural gas; for details refer to A85-222 0
HEATING: Infra-red Heat Lamps Are suitable, providing there are no emissions of light in the 600 to 700 Mu range; the true infra-red range will not affect photoperiodicity of the plants. A74-433 0
HEATING: Kerosene Heaters They are safe if vented to the exterior; if there are few flowers to be injured they may be used unvented if adjusted to burn properly. A74-969 0
HEATING: Kerosene Stove Use it only in an emergency; adjust it to a smokeless flame. A78-226 0
HEATING: Lp Gas Heater Unvented it causes yellowing of the leaves and bud drop; it produces ethylene gas; not recommended. A70-345 0
HEATING: Oil Stove Satisfactory if vented to the outside; adjust the flame to burn blue to yellow with no smoke, A71-715 0
HEATING: Wood-burning Stove It could be injurious to the flowers; burning wood emits ethylene; well-vented and not dampered it should be safe. A74-300 0
HEATING: Wood Stove It is not recommended because wood burning produces ethylene, even when vented. A78-13 0

New Topics

  1. Danielle Carbonneau asked question phalaenopsis, dendrochum and Odontoglossum in category Phalaenopsis
  2. Nicholas Filannino asked question Phalaenopsis William Kistler? in category General Discussion
  3. Mark Farran asked question How to open and read articles listed in category General Discussion
  4. Juliann Eckhard started topic Cattleya little susie in category Cattleya Alliance
  5. Shannon Gardea asked question NELLY ISLER in category General Discussion
Ask a Question

Start a Topic

New Comments

  1. Louis Wilson commented on member plant E. alata f. alba by Louis Wilson
  2. Julie Ellner commented on member plant Phal. amabilis var. formosanum by Vickie Seibert
  3. Julie Ellner commented on member plant Rlc. Green Dragoon 'Mendenhall' by Jeanne Uzar Hudson
  4. Danielle Carbonneau commented on member plant Ons. Catatante 'Los Roble' by Henry Shaw
  5. Barry J Silver commented on orchid Lyon. SunCoast Pink Passion
  6. Carol Holdren commented on topic "Phalaenopsis William Kistler?" by Nicholas Filannino
  7. Carol Holdren commented on orchid Colm. Eric Gabriel Heines
  8. Carol Holdren commented on topic "Cattleya little susie" by Juliann Eckhard
  9. Carol Holdren commented on member plant Bc. Morning Glory by Chris Siolo
  10. R .Benson commented on member plant Kir. New Hybrid (Fred Clarke) SVO9831 by R .Benson
  11. Carol Holdren commented on topic "Blooming Stenglottis Venus “jamboree “" by John Urey
  12. Jeanne Uzar Hudson commented on member plant Lc. Canhamiana var. coerulea 'Cobalt' by Jeanne Uzar Hudson
  13. Jeanne Uzar Hudson commented on member plant Sns. gemmata by Jeanne Uzar Hudson
  14. Stefan Neher commented on topic "Orchid roots .com site?" by Mary Lane
  15. Kevin Barry commented on member plant Bul. Tammie Sue Pernas by Tony Pernas
  16. Linda Hartman commented on member plant Ctt. Final Blue by Linda Hartman
  17. Kevin Bergeson commented on member plant Paph. rothschildianum by Kevin Bergeson
  18. Carol Holdren commented on topic "recently purchased orchid shows unstoppable roots " by David George
  19. Michael Makio commented on orchid V. Beatrice Makio
  20. Carol Holdren commented on topic "shorter stem with less vigorous blooms" by katherine mott